Characterisation of silicate scale formation: The effect of pH on silica/silicate scale formation
DOI:
https://doi.org/10.24191/mjcet.v5i2.14999Keywords:
Silicate scale, Alkaline surfactant polymer (ASP) - flooding, Scale morphology, Spectroscopic analysis, Oilfield scaleAbstract
One of the challenging situations that engineers have been encountered in the oil and gas industry is the formation of silicate scale during alkaline surfactant polymer (ASP) flooding which could be throughout the overall production system, from upstream to downstream processes. In the ASP flooding, the ASP slug is injected into the reservoir at a high pH, which is later mixed up with the connate water causing the pH condition inside the reservoir to be reduced. This reduction of pH will aggravate the precipitation of silicate scaling as this type of scale is very much pH-dependent, with the presence of the metallic ion worsening the situation. The main objectives of this study are to characterise and compare (with the pure commercial) the precipitates produced from the Si/Mg system at various pH conditions using spectroscopic analysis, as well as to study the mechanism of silicate scale formation. The precipitates were reproduced from a-Si/Mg scaling brine at room temperature under various pH test conditions. The spectroscopic results confirmed the variation of pH as it propagates within the reservoir from the injection to the production well, producing a different type of morphology. The results obtained showed that pH affects the types and morphology of the precipitation significantly, where the formation of silica/silicate scale is most severe when the value of pH increases whilst Mg-silicate scaling favours pH 8.5.
References
Ahmed, A. F., & Elraies, K. A. (2015). The effect of water salinity and reservoir temperature on silica dissolution during ASP flood: Static model. In M. Awang, B. M. Negash, N. A. Md Akhir, & L. A. Lubis (Eds.), ICIPEG 2014 – Proceedings. https://doi.org/10.1007/978-981-287-368-2.
Ahmed, F. A., Elraies, A. K., Mohammed, A. A., & Gaafar, R. G. (2015). An investigation study on the effect of brine composition on silica dissolution. Advances in Environmental and Geological Science and Engineering, 188–192.
Akstinat, M. (2019) Chemical and physicochemical properties of formation waters of the oil and gas industry, Journal of Hydrology, 578, 124011. https://doi.org/10.1016/j.jhydrol.2019.124011.
Alexander, G.B., Heston, W.M. & Iler, R. K. (1954). The solubility of amorphous silica in water, Journal of Physical Chemistry, 58(6), 453–455. https://doi.org/10.1021/j150516a002.
Amjad, Z. & Zuhl, R. W. (2008, March 16–20). An evaluation of silica scale control additives [Conference presentation]. NACE International Corrosion Conference and Expo 2008, New Orleans, USA.
Arensdorf, J., Hoster, D., McDougall, D., Yuan, M. (2010, June 8–10). Static and dynamic testing of silicate scale inhibitors [Conference presentation]. CPS/Society of Petroleum Engineers International Oil and Gas Conference and Exhibition, Beijing, China.
Basbar, A. E. A., Elraies, K. A. & Osgouei, R. E. (2013, April 15–17) Formation silicate scale inhibition during alkaline flooding: static model [Conference presentation]. North Africa Technical Conference & Exhibition 2013, Cairo, Egypt.
Bello, O. (2017). Calcium carbonate scale deposition kinetics on stainless steel surfaces (uk.bl.ethos.715071) [Doctoral Thesis, The University of Leeds]. White Rose eTheses Online.
Brown, K. (2011, May 25–27). Thermodynamics and kinetics of silica scaling [Conference presentation]. International Workshop on Mineral Scaling 2011, Manila, Philippines.
Chandrasekhar, S. & Mohanty, K.K. (2013, September). Wettability alterations with brine composition in high temperature carbonate reservoirs [Conference presentation]. The SPE Annual Technical Conference and Exhibition 2013, New Orleans, Louisiana, USA. https://doi.org/10.2118/166280-MS.
Demadis K.D. (2010). recent development in controlling silica and magnesium silicate foulants in industrial water systems. In Amjad, Z. (Ed.) The Science and Technology of Industrial Water Treatment. (pp. 179–203). Taylor and Francis Group, LLC, USA.
Demir, M. M., Baba, A., Atilla, V., & İnanlı, M. (2014). Types of the scaling in hyper saline geothermal system in northwest Turkey. Geothermics, 50, 1–9. https://doi.org/10.1016/j.geothermics.2013.08.003.
Fathi, S. J., Austad, T., & Strand, S. (2010). Smart water as a wettability modifier in chalk: The effect of salinity and ionic composition. Energy & Fuels, 24(4), 2514–2519. doi:10.1021/ef901304m.
Gill, J. S. (1993). Inhibition of silica-silica deposit in industrial waters. Colloids and Surfaces, 74(1), 101–106. https://doi.org/10.1016/0927-7757(93)80401-Y.
Gill, J. S. (1998, March 22–27). Silica scale control [Conference presentation]. The NACE International Corrosion 1998, San Diego, California, USA.
Gunnarsson, A., & Arnórsson S. (2005). Impact of silica scaling on the efficiency of heat extraction from high-temperature geothermal fluids, Geothermics, 34(3), 320–329. http://doi.org/10.1016/j.geothermics.2005.02.002.
Gunnarsson, A., & Arnórsson, S. (2003, September 14–17) Silica scaling: The main obstacle in efficient use of high-temperature geothermal fluids [Conference presentation] The International Geothermal Conference 2003, Reykjavík, Iceland. https://rafhladan.is/bitstream/handle/10802/9400/S13Paper118.pdf?sequence=1 (Accessed: 20 March 2015).
Guo, H., Li, Y., Wang, F., Yu, Z., Chen, Z., Wang, Y., & Gao, X. (2017). ASP flooding: theory and practice progress in China. Journal of Chemistry, 2017, 1–18. https://doi.org/10.1155/2017/8509563.
Gupta, R., Smith, P.G.J., Hu, L., Willingham, T.W., Cascio, M.L., Shyeh, J.J. & Harris, C.R. (2011, September 25). Enhanced waterflood for middle east carbonate cores – Impact of injection water composition [Conference presentation]. The Society of Petroleum Engineers (SPE) Middle East Oil and Gas Show and Conference 2011, Manama, Bahrain. http://doi.org/10.2118/142668-MS.
Icopini, G.A., Brantley, S.L., & Heaney, P.J. (2005) Kinetics of silica oligomerization and nano colloid formation as a function of pH and ionic strength at 25°C. Geochimica et Cosmochimica Acta, 69(2), 293–303. https://doi.org/10.1016/j.gca.2004.06.038.
Joni, I. M., Nulhakim, L., Vanitha, M., & Panatarani, C. (2018). Characteristics of crystalline silica (SiO2) particles prepared by simple solution method using sodium silicate (Na2SiO3) precursor. Journal of Physics: Conference Series, 1080, 012006. https://doi.org/10.1088/1742-6596/1080/1/012006.
Kashpura, V. N. & Potapov, V. V. (2000, January 24–26). Study of the amorphous silica scales formation at the Mutnovskoe hydrothermal field (Russia) [Conference presentation] Twenty-Fifth Workshop on Geothermal Reservoir Engineering, Stanford, California, USA.
Kazempour, M., Sundstrom, E., & Vladimir, A. (2011, May). Geochemical modelling and experimental evaluation of high-pH floods: Impact of water-rock interactions in sandstone [Conference presentation] The SPE EUROPEC/EAGE Annual Conference and Exhibition, Vienna, Austria. https://doi.org/10.2118/143479-MS
Keshavarz, M., &Ahmad, N. (2013). Characterization and modification of mesoporous silica nanoparticles prepared by sol-gel. Journal of Nanoparticles, 2013, 102823, https://doi.org/10.1155/2013/102823.
Kohli, R. & Mittal, K.L. (2019). Developments in surface contamination and cleaning: Methods for assessing surface cleanliness., 12, 23–105 Elsevier, ISBN 9780128160817.
Kohli, R., & Mittal, K.L. (2019). Characterization of surface contaminants and features. Developments in Surface Contamination and Cleaning, 12, 107–158 Elsevier, ISBN 9780128160817, https://doi.org/10.1016/B978-0-12-816081-7.00004-8.
Lu, H., Brooks, J., Legan, R., & Fritz, S. (2018, June 20–21). Novel laboratory test method and field applications for silica/silicate and other problematic scale control [Conference presentation]. The SPE International Oilfield Scale Conference and Exhibition 2018, Aberdeen, Scotland, UK.
Merdhah A.B.B., & Yassin, A.A.M. (2009). Strontium sulphate scale formation in oil reservoir during water injection at high-salinity formation water, Asian Journal of Applied Science, 2, 300–317. https://doi.org/ 10.3923/ajaps.2009.300.317.
Meyers, P. (1999, October 18–20). Behaviour of silica in in exchange and other systems [Conference presentation]. The International Water Conference: 60th Annual Meeting, Pittsburgh, Pennsylvania, USA.
Meyers, P. (2004). Behaviour of silica: Technologies available and how they rate. Arizona, US: Water Conditioning & Purification Magazine.
Moustafa, El-A.A.A. Shedid, A. S. (2018). Effects of magnesium and potassium sulphates on oil recovery by water flooding. Egyptian Journal of Petroleum, 27(4), 649–656, https://doi.org/10.1016/j.ejpe.2017.09.007.
Ning, R.Y. (2002). Discussion of silica speciation, fouling, control and maximum reduction, Desalination, 151(1), 67–73.
Rodríguez, A. (2006). Amorphous iron silicate scales in surface pipelines: characterization and geochemical constraints on formation conditions in the Miravalles Geothermal Field, Costa Rica, Geothermal Training Programme, Report 2006, No. 19, The United Nation University.
Sazali, R. A. (2018). The development of a test methodology and new findings in silicate scale formation and inhibition [Doctoral dissertation, Heriot-Watt University].
Sazali, R.A, Sorbie, K., Boak, L., & Heriot Watt University. (2015). The effect of pH on silicate scaling [Ebook]. Society of Petroleum Engineer.
Sheng, J.J. (2014). A comprehensive review of alkaline–surfactant–polymer (ASP) flooding, Asia-Pacific Journal of Chemical Engineering, 9(4), 471–489. http://doi.org/10.1002/apj.1824.
Sonne, J., Kerr, S., & Miner, K. (2012b, May 30–31) Application of silicate scale inhibitors for ASP flooded oilfields: A novel approach to testing and delivery [Conference presentation]. The SPE International Conference and Exhibition on Oilfield Scale 2012, Aberdeen, UK. https://doi.org/10.2118/154332-MS.
Sonne, J., Miner, K., & Kerr S. (2012a, April 16–18) Potential for inhibitor squeeze application for silicate scale control in ASP flood [Conference presentation]. The SPE EOR Conference at Oil and Gas West Asia 2012, Muscat, Oman.
Tavangarian, F., & Emadi, R. (2010). Synthesis of pure nanocrystalline magnesium silicate powder. Ceramics - Silikaty, 54(2), 122–127.
Umar, A. A. & Saaid, I. M. (2014). Effects of temperature on silicate scale inhibition during ASP flooding, Journal of Applied Sciences, 14(15), 1769–1774. doi: 10.3923/jas.2014.1769.1774.
Utami, W. S., Herdianita, N. R., & Atmaja, R. W. (2014). The effect of temperature and pH on the formation of silica scaling of Dieng geothermal field, Central Java, Indonesia, Thirty-Ninth Workshop on Geothermal Reservoir Engineering, Stanford University, Stanford, California – Proceedings.
van den Heuvel, D. B., Gunnlaugsson, E., Gunnarsson, I., Stawski, T. M., Peacock, C. L., & Benning, L. G. (2018). Understanding amorphous silica scaling under well-constrained conditions inside geothermal pipelines. Geothermics, 76, 231–241. doi:10.1016/j.geothermics.2018.07.006.
Wei, J., Tao, J., Xin, S., Zhang, Q., Zhang, X., & Wang, Z. (2011, July 2011) A study on alkali consumption regularity in minerals of reservoirs during alkali (NaOH)/surfactant/polymer flooding in Daqing oilfield [Conference presentation]. The SPE Enhanced Oil Recovery Conference, Kuala Lumpur, Malaysia. doi: https://doi.org/10.2118/142770-MS.
Zulfiqar, U., Subhani, T., & Husain, S. (2015). Synthesis and characterization of silica nanoparticles from clay [Ebook]. Elsevier.
Downloads
Published
How to Cite
Issue
Section
License
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
